Announcement

Collapse
No announcement yet.

Big Dog's Rig Build Up

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • #46

    Template in place, with the instructions at hand(Safari, 4WD Action and most importantly PP)

    Everything marked out ready to drill, very nervous at this point.


    Got the holes drilled, not the best edge on the 95mm hole but bit of a file and some paint and job done. If you’re going to do this deffinately get a step drill, best money I’ve spent.
    From this point things got tricky and I didn’t take any photos, nothing complicated just akward, trying to get the nuts on inside the inner guard (you should get a racheting spanner for this, it would have made life much easier), lining up the z piece that links the snorkle to the airbox and tighten up the hose clamps but job done

    and I reckon it looks pretty good.
    Big Dog
    [B]2008 GREY GXL D4D[/B] with Sovereign Bar, PP Sticker, IPF 900 Spot/Spread Blue Covers, GME3440 UHF, AMTS Spacers, 275/65 R17 BFG's, Autocraft Sliders/Steps, Safari Snorkle, Hilux Washers, ARB Alloy Roof Rack, Ironman Awning [B]Yet To Come[/B] - 2" Lift, Dual Battery, AMTS Bash Plates, DIY Drawers, Diff Breathers, Rear Locker....Much More.

    Comment


    • #47
      Hilux Washer Upgrade - Best Mod on PP...

      One of the best upgrades on Pradopoint, the guys on here are incredibly clever.

      Picked these up from Toyota for just less than $50.

      Pop the front of the washer with a zip tie (use one of the larger ones, the small ones aren’t stiff enough)

      Hold the front and pop the back.

      Then lift it out, pull it off and put the new one on. Too Easy.
      Big Dog
      [B]2008 GREY GXL D4D[/B] with Sovereign Bar, PP Sticker, IPF 900 Spot/Spread Blue Covers, GME3440 UHF, AMTS Spacers, 275/65 R17 BFG's, Autocraft Sliders/Steps, Safari Snorkle, Hilux Washers, ARB Alloy Roof Rack, Ironman Awning [B]Yet To Come[/B] - 2" Lift, Dual Battery, AMTS Bash Plates, DIY Drawers, Diff Breathers, Rear Locker....Much More.

      Comment


      • #48
        Hilux Washer Upgrade...



        And this is the end result.
        Big Dog
        [B]2008 GREY GXL D4D[/B] with Sovereign Bar, PP Sticker, IPF 900 Spot/Spread Blue Covers, GME3440 UHF, AMTS Spacers, 275/65 R17 BFG's, Autocraft Sliders/Steps, Safari Snorkle, Hilux Washers, ARB Alloy Roof Rack, Ironman Awning [B]Yet To Come[/B] - 2" Lift, Dual Battery, AMTS Bash Plates, DIY Drawers, Diff Breathers, Rear Locker....Much More.

        Comment


        • #49
          ARB Battery Tray Install - For Compressor Mounting

          I have been planning on installing an ARB Battery Tray to install my compressor under the bonnet. I came across one on ebay for $100. Couple of conversations with the guys at ARB had suggested I needed an extra kit to install it. Thought I’d take a look at it first before shelling out any extra.



          The arrangement before starting, hard to picture it fitting in this space.



          Fuel Filter disconnected and removed, old fuel filter bracket removed and all cables unclipped below.



          There was nothing in the ARB instructions about this but I disconnected this hose to put the wiring harness below.



          This is what I assume the extra bracket would have been for. Originally I could not get this plug to fit in below this unit due to a part of the bracket that stuck up between the two bolts you can see. So I modified it by cutting out the raised section, allowing the plug to fit below it nicely.
          Big Dog
          [B]2008 GREY GXL D4D[/B] with Sovereign Bar, PP Sticker, IPF 900 Spot/Spread Blue Covers, GME3440 UHF, AMTS Spacers, 275/65 R17 BFG's, Autocraft Sliders/Steps, Safari Snorkle, Hilux Washers, ARB Alloy Roof Rack, Ironman Awning [B]Yet To Come[/B] - 2" Lift, Dual Battery, AMTS Bash Plates, DIY Drawers, Diff Breathers, Rear Locker....Much More.

          Comment


          • #50
            ARB Battery Tray Install - For Compressor Mount

            Cont...



            I separated out these two wires to reconnect back up to the fuel filter. While trying to get one of the zip ties off, the stanley knife slipped, not to worry though, my hand stopped it from hitting anything important.



            The tray itself needed a bit of a tidy up as well, so cleaned it up and repainted it.



            Everything back in with the new tray in place. Shortened the two fuel lines so they wouldn’t kink. Probably need to lengthen the two wires to the sensor at the top of the filter. The tray is very solid and will be a great spot for the compressor – don’t have an ARB compressor at the moment, but the MegaGrunt MX3 should fit. Will probably mount my Redarc Isolator on the side of the tray too.
            Big Dog
            [B]2008 GREY GXL D4D[/B] with Sovereign Bar, PP Sticker, IPF 900 Spot/Spread Blue Covers, GME3440 UHF, AMTS Spacers, 275/65 R17 BFG's, Autocraft Sliders/Steps, Safari Snorkle, Hilux Washers, ARB Alloy Roof Rack, Ironman Awning [B]Yet To Come[/B] - 2" Lift, Dual Battery, AMTS Bash Plates, DIY Drawers, Diff Breathers, Rear Locker....Much More.

            Comment

            canli bahis siteleri bahis siteleri ecebet.net
            mencisport.com
            antalya escort
            tsyd.org deneme bonusu veren siteler
            deneme bonusu veren siteler
            gaziantep escort
            gaziantep escort
            asyabahis maltcasino olabahis olabahis
            erotik film izle Rus escort gaziantep rus escort
            atasehir escort tuzla escort
            sikis sex hatti
            en iyi casino siteleri
            deneme bonusu veren siteler
            casibom
            deneme bonusu veren siteler
            deneme bonusu veren siteler
            betticket istanbulbahis
            Working...
            X